EMAK OM124J Owner's Manual download pdf (Page 19)

MACHINE CONTROL ENGLISH

6.2 OPERATION AND ATTENDANCE

Machine safety protection

The mowing machine is equipped with safety contacts which are closed by:

- switch placed under the seat

- switch of the grass collection bin suspending, or deflector

- switch of the grass collection bin fill-up

- switch of the travel pedal

The engine will automatically stop if the driver leaves the seat. The engine can only be started up if the mowing mechanism is switched off and the grass

collection bin is suspended, or the deflector is attached, which prevents the mowed grass from the entering into the inlet tunnel of the collecting bin dur-

ing mulching.

6.2.1 SUSPENSION OF GRASS COLLECTION BIN

Grasp the grass collection bin with both hands and lift it. Tilt it so that it is reclinedin the 40° angle and suspend it on two brackets located on the rear

side of the machine. The tops of yellow triangle labels must be opposite each other (see the section 4.2.7).

6.2.2 ENGINE START

• Check the petrol level in the tank.

• Open the petrol supply closure - valid only for BS15 engines with a power output of 15.5 HP

• Sit down on the machine seat comfortably, shift the mowing mechanism height adjustment lever 6.1.17 to position "7".

• Set the mowing mechanism switch 6.1.1 to the "OFF" position.

• Caution, do not step on the travel pedal 6.1.14.

• Set the gas control lever 6.1.3 to the "MAX“ position - only on machines with an engine that has apower output of 16 HP and higher.

• Set the gas control lever 6.1.3 to the "CHOKE“ position - only on machines with BS15 engines with a power output of 15.5 HP.

• Pull out choke 6.1.4 - only on machines with an engine that has a power output of 16 HP and higher.

• Do not manipulate the mowing mechanism height adjustmentlever 6.1.17.

• Turn the ignition key 6.1.2 to the "START“ position.

The time of start must not exceed 10 seconds – if this time is exceeded, damage to the battery may be caused.

• The engine "is running" - release the ignition key. The key will automatically return to the "ON" position.

• push choke 6.1.4 inwards gradually - only on machines with an engine with apower output of 16 HP and higher.

• Set the gas control lever 6.1.3 slowly to the "MIN" position (reduce the engine speed).

• Let the engine run for several minutes before turning on the mowing mechanism.

6.2.3 ENGINE STOP

• Set the gas control lever 6.1.3 to the "MIN" position.

• Turn off the mowing mechanism using switch 6.1.1 (see the section 6.2.4).

• If the engine is overheated, let it run for a while at minimum revolutions.

• Turn off the engine with key 6.1.2 rotation to the "STOP" position and remove the key from the ignition.

6.2.4 MOWING MECHANISM TURNING ON AND OFF

a) Turning on

• Set the gas control lever 6.1.3 to the "MAX" position.

• Set the working position of the mowing mechanism and with it also the height of mowing by the mowing mechanism height setting-up lever (see the

section 6.1.17 and 6.2.5).

• Set the mowing mechanism switch 6.1.1 to the "ON" position.

The mowing mechanism will be switched on provided:

- operator is sitting on the machine seat

- grass collection bin is suspended, contingently the deflector is put in

- switch AUT/MAN 6.1.9 (only for models equipped with switch AUT/MAN 6.1.9) is in the "AUT" position and the basket is empty.

- AUT/MAN switch 6.1.9 is in the "MAN" position - valid only for models equipped with the AUT/MAN switch

b) Turning off

• Set the mowing mechanism switch 6.1.1 to the "OFF" position.

• If the driver leaves the seat, the engine will stop automatically, as well as the rotation of the mowing blades.

WARNING !!!

Never switch off the mowing mechanism by just getting off the seat. Unless you switch the ignition key from the "ON" position

to the "OFF" (STOP) position, a part of the electrical installation is still live which may lead to damages.

IMPORTANT

Before turning the ignition off, reduce the engine revolutions to slow speed in the event ofself-ignition, not observing this instruction

may result in damage to the engine and exhaust.

WARNING !!!

Never stop the engine by just getting off the seat, as the key left in the ignition switch may cause a defect in electrical installation.

Always rotate the key to the "OFF" position and remove it from the switch box.

DANGER !

Never leave the engine running in a closed or poorly ventilated room. Exhaust fumes containing carbon monoxide are very dangerous.

Keep Your hands, legs and loose clothes out of the reach of moving parts and of the exhaust.

1 2 ... 14 15 16 17 18 19 20 21 22 23 24 ... 29 30

Comments to this Manuals

No comments

EMAK OM124J Owner's Manual Page 19

Comments to this Manuals

Related products and manuals for Lawnmowers EMAK OM124J